Solar Water Heater Maintenance Checklist

Solar water heating system maintenance and repair periodic inspection list.

Solar water heater maintenance checklist.

Whether the tank is gas or electric turn off its heating source the night before. Here are some suggested inspections of solar system components. Annual water heater maintenance checklist drain and flush tank drain and flush tank very important for gas water heaters. Two major factors affecting the performance of properly sited and installed solar.

Check to make sure the water to the hot water heater has been completely shut off. Install pump onto the water heater discharge using pipe fitting. When calling for assistance please have the following. Satisfactory not satisfactory 2 quantity of hot water supply.

Satisfactory not satisfactory 3 constant temperature e g. Open a hot water. Disconnect the hot water heater at the hot water discharge. 1 temperature of hot water.

Allow a few gallons worth of water to drain. Close drain valve and open cold water supply valve. If that is too. Solar storage tank water heater installation instructions and use care guide to obtain technical warranty or service assistance during or after the installation of this solar storage tank water heater reference the phone number on the warranty sheet that ships with the water heater.

Use a solution of dish soap and warm. The pump should be installed so that the pump is pumping away from the hot water heater towards the solar panel. Regularly scheduled maintenance should include. If water is milky drain entire tank.

Before you begin inspect all of the valves. Among the parts that should be checked regularly on your solar water heater are pumps valves and their controls insulation wiring pipes seals and the state of the solar collector. Drain 2 3 gallons of water. Drain the water from the hot water pipe.

Don t miss the temperature and pressure valves. Be sure to check the water draining out and make sure it is clear. Also read your owner s manual. Preventing scaling and corrosion.

Checking the solar collectors and frames for damage noting broken or leaking tubes for replacement ensuring valves are in proper positions inspecting pipe insulation to minimize losses and maintain freeze protection checking mounting connectors for. With pressure valve still open turn on the water to the water tank and then turn on the water drain to allow the rest of the sediment to be flushed out. Turn off cold water supply and open drain valve. Turn off the heat.

Solar hot water heaters are no different except that because they have more components there is more that can go wrong.